Loading
With the exception of heavy duty models and some parking deck covers (for point loads up to 907kgs)
all joints are typically designed to withstand normal pedestrian traffic (for loads up to 227kgs). For any
other loading requirement we strongly recommend consultation with our Technical Department. Installation
must be in accordance with the instructions supplied with materials.
C/S TPR (Thermoplastic Rubber)
Gasket - Physical Properties
- Brittle Temperature: -39.5°C
- Flame Test: Self Extinguishing
- For information on C/S TPR Gasket’s chemical resistance please contact us on 01296
611066.
Installation Recommendations
Bedding
It is normally necessary to apply non-shrink, self-levelling bedding compound on top of concrete floor slabs in order to provide a level,
even and structurally sound base over the entire width and length of the expansion joint cover base frame.
Fixings
Fixings for any expansion joint cover system will inevitably tend to be close to the edge of the concrete floor slab. It is therefore essential
that any fixings used should not exert an excessive sideways force, which might fracture the concrete along the side of the floor slab.
Production Design
The company reserve the right to make design changes for the purpose of product improvement, or to withdraw any design without notice.
Stock
Stock is held in lengths of 3metres. Custom lengths are available to special order. To check stock please call 01296
611066.
|
Colours
Aluminium sections are supplied mill finished as standard, with the exception of exposed aluminium covers and frames which are generally
supplied clear anodised. Coloured anodising or powder coating is available as special option, subject to minimum quantity.
Stainless steel sections are supplied dull polished as standard.
Standard C/S TPR Gaskets are available in:
Samples
Available from your local C/S representative or C/S direct.
C/S Advisory Service
Construction Specialties representatives are fully trained and experienced in all aspects of
specification and installation and can offer expert advice if required.
Warranty Policy
Construction Specialties (UK) Ltd (the Company) warrants to its customers that all expansion
joint covers sold by it will be free from any defects in materials and workmanship and will meet the
design criteria noted in our detail manual when properly applied and installed. If, in the sole opinion
of the company, a product covered by this warranty is defective the company will replace or repair it
free of charge. This warranty shall extend for a period of one year following the date of shipment by
the company. This is in lieu of all other warranties expressed or implied and is the sole warranty
extended by the company. The liability of the company under this warranty is limited to repair or
replacement and does not include any responsibility for consequential or other damage of any nature. |
01296 611066
Overview
Technical
